注意三個事項防止攪拌機在運轉中出現小毛病
來源：http://www.wishnailspa.com/日期：2022-12-23
概述：混凝土攪拌機主要包括三部分:電動機、攪拌棒和攪拌密封裝置。注意三個事項防止攪拌機在運轉中出現小毛病，下面混凝土攪拌機廠家為您解答。
混凝土攪拌機主要包括三部分:電動機、攪拌棒和攪拌密封裝置。注意三個事項防止攪拌機在運轉中出現小毛病，下面
混凝土攪拌機廠家為您解答。
Concrete mixer mainly includes three parts: motor, mixing bar and mixing sealing device. Pay attention to three items to prevent minor problems during the operation of the mixer, and the concrete mixer manufacturer will answer them for you.
一、安裝前的注意事項
1、 Precautions before installation
1.請注意攪拌機須順時針方向運轉（由上往下看朝右轉方向）。
1. Please note that the mixer must operate clockwise (from top to bottom, turn right).
2.當您使用攪拌機時，需要適當容量的電源。如果使用了小容量的電源，便有可能會發生無法啟動的清形，請千萬注意電源容量。
2. When you use the mixer, you need a power supply of appropriate capacity. If a small capacity power supply is used, it is possible to fail to start. Please pay attention to the power capacity.
3.請確認您使用的頻率及電壓是否和銘牌記載的規格相同。（尤其是以發動機供電時，更須注意頻率及電壓的變動）。
3. Please confirm whether the frequency and voltage you use are the same as those recorded on the nameplate. (Especially when the power is supplied by the engine, pay more attention to the change of frequency and voltage).
4.請在混凝土攪拌機的額定電壓變動之容許值的±10%以內使用電壓。
4. Please use the voltage within ± 10% of the allowable value of the rated voltage change of the concrete mixer.
5.移動攪拌機時，千萬不可以拉電纜線，以免電纜線破裂，絕緣下降造成漏電。
5. When moving the mixer, do not pull the cable to avoid breakage of the cable and electric leakage caused by insulation drop.
二、操作中的方法及注意事項
2、 Methods and precautions in operation
1.攪拌機操作前，先檢查所用電源之電壓及頻率是否與銘牌上標示相符。
1. Before operation of the mixer, check whether the voltage and frequency of the power supply are consistent with those on the nameplate.
2.檢查液位是否正常，以免影響攪拌機的使用效果
2. Check whether the liquid level is normal, so as not to affect the use effect of the mixer
3.注意攪拌機有無異常的振動及噪音產生。
3. Pay attention to whether the mixer has abnormal vibration and noise.
4.控制盤置于自動位置，勿轉于手動位置，以免攪拌機無水運轉。注意運轉時，水位不可低于混凝土攪拌機攪拌槳葉。
4. The control panel shall be placed in the automatic position and not in the manual position to prevent the mixer from running without water. During operation, the water level shall not be lower than the mixing blade of the concrete mixer.
三、日常維護的注意事項
3、 Precautions for routine maintenance
1.如果發現攪拌機有異常振動及噪音時須檢視軸承是否損壞，須時更換軸承。
1. If the mixer is found to have abnormal vibration and noise, check whether the bearing is damaged, and replace the bearing when necessary.
2.平時注意水質是否與選用攪拌機時有所差異，含沙量、水質的酸堿度等，如有變化，須更換適當?shù)臋C械軸封。
2. At ordinary times, pay attention to whether the water quality is different from that of the mixer, such as the sand content and the pH of the water. If there is any change, replace the appropriate mechanical shaft seal.
3.當攪拌機無法工作時，便須檢查攪拌葉輪是否有異物卡住，如有須立即。
3. When the mixer cannot work, check whether there are foreign matters stuck on the mixing impeller, and remove them immediately if any.
The above is the answer to the three matters to be noted to prevent minor problems during the operation of the mixer. If you have any needs or doubts, you can come to our website at any time http://www.wishnailspa.com Understand!
全國服務熱線
點擊撥打服務熱線：400-879-1999
