冬天天氣寒冷，什么東西都容易上凍，那么這種天氣下應當如何保養好混凝土攪拌機呢。攪拌機保養時，底盤護理容易忽略的司機朋友，但在冬季或潮濕的天氣的好壞底盤的重要性是顯而易見的。

It's cold in winter, everything is easy to freeze, so how to maintain the concrete mixer in this weather. Mixer maintenance, chassis care is easy to ignore the driver friend, but in winter or wet weather the importance of good or bad chassis is obvious.

在冬天要做底盤底盤將會徹底的清洗和防銹處理。對底盤進行徹底清潔，如果底盤上太多的污垢，用脫脂洗滌劑洗一遍，使底盤給原來的“本能”，所以防銹護理就可以開始了。在美容院，混凝土泵車可以到吊架底盤清洗、擦拭，然后防銹護理。中間的注意，清洗后必須等到底盤水分干透后，防銹劑保健。照顧，一定要保持噴霧均勻應用涂料，形成一層保持持久的統一的防銹涂料。所有自然干燥后再進行5 - 10分鐘完成，為了完成底盤防銹處理。

In winter to do chassis, chassis will be thoroughly cleaned and antirust treatment. First of all, clean the chassis thoroughly. If there is too much dirt on the chassis, wash it with degreasing detergent once to make the chassis give the original "instinct". Therefore, rust prevention care can start. In the beauty salon, the concrete pump truck can go to the hanger chassis to clean, wipe, and then rust protection. In the middle of the attention, after cleaning must wait until the chassis moisture dry, antirust agent health care. Care must be taken to keep the spray evenly applied and form a durable and uniform rust preventive coating. All natural drying after 5 - 10 minutes to complete, in order to complete the chassis antirust treatment.
              

你去做卡護理沙龍，它的質量是好是壞，有一個簡單的方法來嘗試：底盤防銹護理后的高壓水噴不掛水，所以代表的效果是關心，才會有很好的防銹。

If you go to the card care salon, whether its quality is good or bad, there is a simple way to try: the high-pressure water spray after the chassis antirust care does not hang water, so the representative effect is care, and there will be good rust prevention.

當攪拌機在野外或遠離攪拌機和會見底盤零部件損壞，針對不同故障情況，可以利用以下急救方法將車車庫條件。

When the mixer is in the field or far away from the mixer and meets the chassis parts damage, the following emergency methods can be used to change the garage conditions according to different fault conditions.

剎車制動液泵泄漏或分?jǐn)啾霉?，可以在點由于三叉做了一個小墊鐵，銅，阻塞管道，然后擰緊螺絲，或夾斷口平坦，泄漏，不能使車輪制動器使用。但是這樣做可能會造成單邊制動，開車時要注意。

If the brake fluid pump leaks or breaks off the pump pipe, a small pad iron and copper can be made at the point to block the pipe, and then the screw is tightened, or the fracture surface of the clamp is flat and leaking, so the wheel brake can not be used. However, this may result in unilateral braking. Pay attention to safety when driving.

制動主缸，制動液可以代替酒精或白酒，特殊情況下可以代替水。制動杯膨脹，膨脹的杯熱水浸泡10分鐘20分鐘，組成的油杯，這樣你就可以恢復原始大小的杯子。

Brake master cylinder, brake fluid can replace alcohol or liquor, in special cases can replace water. The brake cup is inflated and the inflated cup is soaked in hot water for 10 to 20 minutes to form an oil cup, so you can restore the original size of the cup.

離合器摩擦片消融滑動、摩擦片燒蝕不太嚴重，可以用來翻轉。如燒蝕嚴重，可用棉布或帆布層(其厚度應符合原始摩擦盤)，鋼絲或鐵絲穿過鋼片上的孔，使其固定。當駕駛車輛應開始順利，迅速轉移行動。

Clutch friction plate ablation sliding, friction plate ablation is not too serious, can be used to flip. If the ablation is serious, cotton cloth or canvas layer (its thickness should be consistent with the original friction disc) can be used, and steel wire or iron wire can be passed through the hole on the steel plate to make it fixed. When driving a vehicle should begin smoothly, move quickly.

混凝土攪拌機拉桿球接頭失敗，保險杠或其他不影響開車，卸載一個類似于球關節螺釘?shù)目傞L度，球形接頭的失敗，而是轉向節臂安裝螺母，螺栓顯示良好的用錘子鉚接。三軸車輛差速齒輪損壞，如后橋差速器損壞，任何一個橋可以驅動軸，驅動軸，繼續開車。如果是前者微分損傷，輪轂接合板可以刪除。

Concrete mixer pull rod ball joint failure, bumper or other does not affect the start-up, unload a similar to the total length of ball joint screw, spherical joint failure, but steering knuckle arm mounting nut, bolt shows good riveting with hammer. If the differential gear of the three axle vehicle is damaged, if the rear axle differential is damaged, any axle can drive the shaft, drive shaft and continue driving. If the former is differential damage, the hub joint plate can be deleted.