混凝土攪拌機出現以下五種情況，就需要保養了！

Concrete mixer in the following five cases, it needs maintenance!

1.異常噪音

1. Abnormal noise

如果混凝土攪拌機在行駛過程中發出奇怪的噪音，應立即下車檢查，或前往維修點進行故障排除。千萬不要讓攪拌機“帶病工作”。萬一路上發生事故，對施工和自身都有很大影響。

If the concrete mixer makes strange noise during driving, you should get off the car immediately for inspection or go to the professional maintenance point for troubleshooting. Don't let blenders work with diseases. In case of an accident on the road, it has a great impact on the construction and itself.

2.高溫過熱

2. High temperature and overheating

高溫過熱主要發生在攪拌機的發動機、變速器、制動器等設備上。如果發動機過熱，大多是冷卻系統有問題，冷卻液不足或者泵不工作；如果變速器和驅動橋過熱，很可能是潤滑油不足；制動器過熱大多是由于制動蹄無法返回造成的。這些現象可以直接反映在儀表盤的警示燈上，而不會分散太多的注意力，只要司機開車時注意觀察就可以了。

High temperature overheating mainly occurs in the mixer engine, transmission, brake and other equipment. If the engine overheats, most of the problems are the cooling system, insufficient coolant or the pump does not work; If the transmission and drive axle overheat, it is likely that the lubricating oil is insufficient; Brake overheating is mostly caused by the brake shoes can not return. These phenomena can be directly reflected in the warning light of the instrument panel, and will not distract too much attention, as long as the driver pays attention to observe when driving.

3.工作不正常

3. Abnormal work

工作狀況指的是攪拌機在行駛或攪拌混凝土?xí)r出現不正?，F(xiàn)象。這些現象包括發動機突然熄火后很難啟動或不能啟動；發動機在工作中動力突然降低，或者制動失靈或跑偏等。這類故障比較明顯，比較容易察覺。

Working condition refers to the abnormal phenomenon when the mixer is running or mixing concrete. These phenomena include that it is difficult to start or unable to start the engine after sudden flameout; When the engine is working, the power suddenly decreases, or the brake fails or deviates. This kind of fault is obvious and easy to detect.
                    

4.液體泄漏

4. Liquid leakage

泄漏的液體主要包括發動機燃油、制動液(壓縮空氣)、動力轉向液等泄漏現象。這種毛病，仔細觀察就能發現。漏氣時，可以聽到明顯的漏氣聲。

The leaking liquid mainly includes engine fuel, brake fluid (compressed air) and power steering fluid. This kind of defect can be found by careful observation. In case of air leakage, obvious air leakage can be heard.

5.攪拌機排氣顏色異常

5. The exhaust color of mixer is abnormal

一般情況下，攪拌機發動機排放的煙霧是二氧化碳和水蒸氣。如果廢氣中含有碳?xì)浠衔?、一氧化碳和碳顆粒，廢氣會變成藍色、黑色或白色，這意味著廢氣異常。。但潤滑油上竄氣缸時，尾氣呈藍色；燃燒不完全時，尾氣呈黑色，油中摻水時，尾氣呈白色。

In general, the smoke emitted by the mixer engine is carbon dioxide and water vapor. If the exhaust contains hydrocarbons, carbon monoxide and carbon particles, the exhaust will turn blue, black or white, which means that the exhaust is abnormal.. But when the lubricating oil goes up to the cylinder, the exhaust gas is blue; When the combustion is incomplete, the tail gas is black, and when the oil is mixed with water, the tail gas is white.

以上癥狀說明混凝土攪拌機處于故障狀態。需要及時檢查維護。如果不重視，攪拌機的行駛和工作都會受到很大影響。

The above symptoms indicate that the concrete mixer is in fault state. Timely inspection and maintenance are required. If we don't pay attention to it, the driving and working of the mixer will be greatly affected.