After the concrete mixer is used for a long time with high strength, there will be damage to its parts. It is necessary to do a good job in maintenance. At the same time, there will be a lot of adverse dirt that needs to be dealt with in time. When cleaning the mixer and its wear-resistant parts, it is also necessary to pay attention to the methods.

一、要定期進行保養規程所規定項目的維護、保養作業，如清洗、潤滑、加油等。

1、 It is necessary to regularly carry out the maintenance of the items specified in the maintenance procedures, such as cleaning, lubrication, refueling, etc.

二、混凝土攪拌機開動前要先檢查各控制器是否良好，停工后要用水和石子倒入攪拌筒內10-15分鐘進行清洗，再將水和石子清洗出。操作人員如須進入攪拌筒內清洗時，除切斷電源和卸下熔斷器外，并須鎖好開關箱。

2、 Before the concrete mixer starts, check whether the controllers are in good condition. After the shutdown, pour water and stones into the mixing drum for 10-15 minutes for cleaning, and then wash the water and stones out. If the operator needs to enter the mixing drum for cleaning, he should not only cut off the power supply and remove the fuse, but also lock the switch box.
                

三、禁止用大錘敲打的方法清掃積存在混凝土攪拌機筒內的混凝土，只能用鑿子清掃。

3、 It is forbidden to use the method of hammering to clean the concrete accumulated in the concrete mixer barrel, but only with chisel.

四、在嚴寒季節，工作完畢后應用水清洗攪拌機滾筒并將水泵、水箱、水管內積水放凈，以免水泵、水箱、水管等凍壞。

4、 In the severe cold season, after the work, the mixer drum should be cleaned with water, and the water in the water pump, water tank and water pipe should be drained to avoid freezing damage of the water pump, water tank and water pipe.

不要只注意混凝土攪拌機和攪拌機耐磨配件的維護工作，而忽略了其清洗過程，否則時間久了日積月累會對攪拌機各方面造成較大的副作用。

Do not only pay attention to the maintenance of concrete mixer and its wear-resistant parts, but also ignore the cleaning process, otherwise it will cause great side effects on all aspects of the mixer over time.