攪拌一體機加水操作有哪些特殊？
來源：http://www.wishnailspa.com/日期：2021-09-19
概述：1、攪拌車水箱的水量要經常加滿，以備急用。1 The water tank of the mixer shall be filled frequently for emergency use
1、攪拌車水箱的水量要經常加滿，以備急用。
1. The water tank of the mixer shall be filled frequently for emergency use.
2、水箱加水前，打開放氣閥把箱內空氣放掉，充氣供水后及時關閉貯氣筒。
2. Before adding water to the water tank, open the vent valve to release the air in the tank. After inflating and supplying water, close the air storage cylinder in time.
注意： 水箱僅在供水時加壓,不要帶著加壓水箱在公路上行駛。
Note: the water tank is pressurized only when supplying water. Do not drive on the road with the pressurized water tank.
危險：1）在水箱沒有卸壓之前不可打開進水閥；2）水箱沒有卸壓之前不可開車行駛。
Danger: 1) do not open the water inlet valve before the water tank is depressurized; 2) Do not drive until the water tank has been depressurized.
3、水泥攪拌車冬季停放時，水箱和供水系統里，不得有剩余水。
3. When the cement mixer is parked in winter, there shall be no residual water in the water tank and water supply system.
4、卸料溜槽、加長溜槽是否需要一起使用，由具體工作位置的要求來決定。
4. Whether the discharge chute and extended chute need to be used together depends on the requirements of the specific working position.
5、滿載混凝土正轉時，如要反轉，操縱手柄使正轉停穩后，再操縱手柄反轉。嚴禁正轉過程中操縱手柄使其反轉。
5. When the full load concrete rotates forward, if you want to reverse, the joystick will stop the forward rotation stably, and then the joystick will reverse. It is strictly prohibited to operate the handle to reverse it during forward rotation.
6、攪拌車司機應根據所行走路面坡度情況合理裝料，避免在路上撒料，污染環境。
6. The driver of the mixer truck shall reasonably load materials according to the gradient of the road to avoid spreading materials on the road and polluting the environment.
7、攪拌筒較高并微偏向右（車后看），這種偏向當攪拌筒滿載旋轉時會增加,故該車在轉彎時要很小心。特別是車向左轉時,要更加注意,不要使攪拌筒的轉速超過3r/min。
7. The mixing drum is high and slightly biased to the right (from the rear of the vehicle). This deviation will increase when the mixing drum rotates with full load, so the vehicle should be very careful when turning. Especially when the car turns left, pay more attention not to make the rotating speed of the mixing drum exceed 3R / min.
9、嚴禁攪拌車滿載高速急轉彎。
9. It is strictly prohibited to turn sharply at high speed when the mixer is fully loaded.
10、非操作人員，禁止操作。
10. Non operators are not allowed to operate.
11、下班后，將水泥攪拌車及進料斗、攪拌筒內外、出料溜槽等清洗干凈。把車門鎖好，轉動鎖緊手柄，鎖牢油門手柄和伺服手柄。
11. After work, clean the cement mixer truck, feed hopper, inside and outside of the mixing drum, discharge chute, etc. Lock the door, turn the locking handle, and lock the throttle handle and servo handle firmly.
全國服務熱線
點擊撥打服務熱線：400-879-1999
