Where are the accessories of concrete mixer and all-in-one mixer? The accessories of all-in-one mixer are indispensable to the production of mixer. Because some mixers are used for too long, the maintenance is not timely, and coupled with the long-term wind and sun, some parts will be worn or rusted. Therefore, the accessories need to be prepared by customers in advance. What are the common mixer accessories, Where can I buy the concrete mixer? Let's introduce it to you.

中科聚峰攪拌機選用的是耐磨鋼材，此類鋼材有更好的剛度和強度，制成的攪拌機使用壽命更長；而一些小廠家生產的攪拌機，采用的是普通鋼材，成本價格要遠低于耐磨鋼材。尤其是攪拌機易磨損配件的材質，如果質量低劣的話會直接影響到攪拌機的使用壽命。

Zhongke Jufeng mixer adopts high-quality wear-resistant steel, which has better stiffness and strength, and the service life of the mixer is longer; The mixers produced by some small manufacturers use ordinary steel, and the cost price is much lower than that of high-quality wear-resistant steel. In particular, the material of easily worn parts of the mixer will directly affect the service life of the mixer if the quality is poor.

中科聚峰混凝土攪拌機常用配件混凝土攪拌機常用的配件有：襯板，傳感器，大軸，電動滾筒，電磁閥，攪拌電機，料斗滑輪，減速機，攪拌臂、鋼絲繩，軸端密封，葉片，輸送帶，添加劑蝶閥，托輥，行程開關等，這些都比較常見，在施工時應及時更換。

Common accessories of Zhongke Jufeng concrete mixer common accessories of concrete mixer include: lining plate, sensor, large shaft, electric drum, solenoid valve, mixing motor, hopper pulley, reducer, mixing arm, steel wire rope, shaft end seal, blade, conveyor belt, additive butterfly valve, idler, travel switch, etc. These are common and should be replaced in time during construction.

磨損嚴重的混凝土攪拌機配件有葉片、襯板，鋼絲繩，料斗滑輪

The seriously worn concrete mixer accessories include blades, lining plates, steel wire ropes, hopper pulleys

一、葉片、襯板，攪拌機工作是依靠拌筒內攪拌軸上安裝的攪拌葉片，對加入拌筒內的物料進行強力攪動，從而實現對混凝土物料的攪拌。攪拌機轉速較快、葉片易磨損。平均攪拌5-10萬方混凝土后需更換一次。

1、 The work of the blade, lining plate and mixer depends on the mixing blade installed on the mixing shaft in the mixing drum to strongly stir the materials added into the mixing drum, so as to realize the mixing of concrete materials. The rotating speed and blades of the mixer are easy to wear. After mixing 50000-100000 m3 of concrete on average, it needs to be replaced once.

二、鋼絲繩工作中鋼絲繩磨到龍門架易造成磨損，正常情況下6-9個月需更換一次。

2、 During the operation of the steel wire rope, the steel wire rope is easily worn to the gantry, and it needs to be replaced every 6-9 months under normal circumstances.

三、料斗滑輪滑輪長時間負載滾動，易造成磨損?；喼灰苡萌庋勖黠@觀察出來磨損就必須進行更換，滑輪只要磨損一部分就會導致料斗上下爬行出現震動，對軌道造成損害，甚導致軌道變形。

3、 The hopper pulley rolls under load for a long time, which is easy to cause wear. As long as the wear of the pulley can be clearly observed with the naked eye, it must be replaced. As long as a part of the pulley is worn, it will cause the hopper to crawl up and down, vibration, damage to the track, and even lead to track deformation.