混凝土攪拌機的操作與運用
來源：http://www.wishnailspa.com/日期：2022-07-15
攪拌機的操作與運用有哪些注意事項？在運用攪拌機的時候要注意什么？今日我們的技術人員為大家談談攪拌機的操作與運用。
What are the precautions for the operation and application of the mixer? What should we pay attention to when using the mixer? Today, our technicians will talk about the operation and application of mixer.
運用前查看：
Check before use:
查看機器運轉是否穩定，支腿是否結實支撐，爬梯支腿墊實狀況。
Check whether the machine operates stably, whether the outriggers are firmly supported, and whether the ladder outriggers are padded.
機器空轉正常。
The machine idles normally.
起動水泵，試泵正常供水。
Start the water pump and test the normal water supply of the pump.
電氣接地杰出。
Excellent electrical grounding.
操作注意事項
Precautions for operation
加入拌和物料不得超過其規則的數值。必須等拌和筒內出料完畢后方能提高上料。
The addition of mixed materials shall not exceed its regular value. Loading can be increased only after the discharge in the mixing drum is completed.
實斗不行隨意下放，遇特殊狀況時，需帶剎車做平穩緩慢下降。
The solid bucket cannot be lowered at will. In case of special conditions, it is necessary to bring the brake to make a steady and slow descent.
為減少粘料現象，料斗加骨料次序應當為：石子>水泥>砂，或許砂>水泥>石子
In order to reduce the phenomenon of sticking, the order of adding aggregate in the hopper should be: Stone > cement > sand, perhaps Sand > cement > stone
上料中要及時加水，減少拌和時間與灰塵的分布。
Add water in time to reduce mixing time and dust distribution.
提高料斗時，禁止任何人在斗下停留?？樟隙废路艜r須緩慢，以增加部件的運用壽命。
When raising the hopper, no one is allowed to stay under the hopper. Empty hopper must be lowered slowly to increase the service life of components.
操縱桿手柄禁止隨意扳動。
It is forbidden to pull the joystick handle at will.
注意電氣，避免電機受潮大型混凝土攪拌機，避免電氣元件、電線遭到損壞。
Pay attention to electrical safety, avoid the motor from being damp, large concrete mixer, and avoid the damage of electrical components and wires.
停電時，用曲柄搖桿來減速箱皮帶盤，可將罐內的物料排出。
In case of power failure, the material in the tank can be discharged by using the crank rocker to reduce the gearbox pulley.
運用后的保養
Maintenance after use
停機前放入少量石子和水，拌和3-5分鐘后放出，重復數次以鏟除筒內的積物。每班工作完畢須將筒內積物鏟除潔凈。
Before stopping the machine, put a small amount of stones and water, mix them for 3-5 minutes, and then release them. Repeat several times to remove the deposits in the barrel. After the completion of each shift, the accumulation in the cylinder must be removed and cleaned.
清洗積灰與全機所粘大型混凝土攪拌機附的混凝土。
Clean the accumulated ash and the concrete attached to the large concrete mixer attached to the whole machine.
將料斗安頓在運輸方位上掛好保險掛鉤。
Place the hopper on the transportation position and hang the safety hook.
切斷電源，鎖好電氣箱。
Cut off the power and lock the electrical box.
冰凍季節應將供水系統內各處剩水排出。
During the freezing season, the remaining water in the water supply system should be discharged.
酌情對各潤滑點加注必要的潤滑油。
Add necessary lubricating oil to each lubricating point as appropriate.
拖行時注意事項：
Precautions when dragging:
查看行大型
混凝土攪拌機走系統的緊固件是否松動，而且用鐵絲將滾筒和底盤固定。
Check whether the fasteners of the walking system of the large concrete mixer are loose, and fix the drum and chassis with iron wire.
拖行速度不大于每小時20。
The towing speed is no more than 20 kilometers per hour.
以上就是今天為大家介紹的關于問題以及注意事項的全部內容，希望對大家能有所幫助，想要了解更多內容可以電話聯系我們或者關注我們的網站
http://www.wishnailspa.com，我們的工作人員會及時與您取得聯系。
The above is all about the problems and precautions introduced to you today. I hope it can help you. If you want to know more, you can contact us by phone or follow our website, and our staff will contact you in time.
全國服務熱線
點擊撥打服務熱線：400-879-1999
