Concrete mixers are very common and can be seen on many construction sites. For the construction of concrete processing, the fuselage should be firmly installed before use, and then tested after installation. Make sure that it can be put into normal operation after installation. The concrete mixer needs to be cleaned and maintained after use. If it is not cleaned for a long time, the concrete will solidify. The following small series will give you an introduction to the operation of concrete mixer need to pay attention to what? And how to clean the concrete mixer after use?

　　一、混凝土攪拌機操作注意事項

　　1、 Precautions for concrete mixer operation

　　1、 攪拌機機身必須安裝平穩牢固。

　　1. The mixer body must be installed stably and firmly.

　　2、作業前應檢查離合器和制動器是否靈活可靠，鋼絲繩有否斷絲損壞。防護裝置是否齊全可靠，并進行試運轉。

　　2. Before operation, check whether the clutch and brake are flexible and reliable, and whether the wire rope is broken or damaged. Whether the protective device is complete and reliable, and the test run is carried out.

　　3、禁止超負荷使用。機械運轉中禁止用手或其他物體伸入拌和筒內去撥弄、清洗和修理等工作。

　　3. Overloading is prohibited. It is forbidden to use hands or other objects to poke, clean and repair the mixing drum during the operation of the machine.
                   

　　4、進料斗升起時，嚴禁任何人在料斗下通過或停留。

　　4. When the feeding hopper is raised, no one is allowed to pass or stay under the hopper.

　　5、料斗應緩緩放下，以免下落速度太快，損壞機件或發生故障。進料斗未停穩前，不得進料。

　　5. The hopper should be put down slowly, so as to avoid falling too fast, damaging the machine parts or failure. Do not feed until the feeding hopper stops stably.

　　6、當攪拌機滿負荷運轉中突然停電或發生故障時，應用人力將拌和筒內存料清出，然后進行檢查或修理。

　　6. In case of sudden power failure or failure during the full load operation of the mixer, the material stored in the mixing drum shall be cleared out by manpower, and then inspection or repair shall be carried out.

　　7、操作人員如必須進入拌和筒內進行清洗或檢修，應嚴格控制電源，以防發生意外事故。

　　7. If the operator must enter the mixing drum for cleaning or maintenance, the power supply should be strictly controlled to prevent accidents.

　　8、在開車清洗時，禁止操作人員爬到進料斗，防止腳碰離合器后，進料斗提升傷人。

　　8. When cleaning the car, it is forbidden for the operator to climb to the feeding hopper to prevent personal injury caused by lifting the feed hopper after the foot touches the clutch.                 

　　二、混凝土攪拌機使用后如何清洗

　　2、 How to clean concrete mixer after use

　　1、混凝土攪拌機在使用前要先檢查各個器件能否正常使用，停工后把一些水和石子放入攪拌桶內開啟電源進行清理15~20分鐘左右，再將水和石子清理出。

　　1. Before using the concrete mixer, check whether all devices can work normally. After shutdown, put some water and stones into the mixing bucket, turn on the power supply for cleaning for about 15 ~ 20 minutes, and then clean the water and stones.

　　2、混凝土攪拌機就像汽車一樣，也需要定期的保養維護。

　　2. Like a car, concrete mixer also needs regular maintenance.

　　3、切記不能用大錘敲擊的方式清理存在混凝土攪拌機筒內已經凝固的混凝土，這樣會損壞機器。

　　3. Remember not to clean the solidified concrete in the concrete mixer barrel by hammering, which will damage the machine.

　　4、在冬季使用時，要注意工作完畢后用水清洗滾筒并將水泵，水箱。

　　4. When using in winter, it is necessary to clean the drum with water and pump and water tank after work.

　　5、每次使用完之后要及時清洗，否則等混凝土凝固之后就會很難清洗，費時又費力。

　　5. After each use, it should be cleaned in time, otherwise it will be difficult to clean after the concrete is set, which is time-consuming and laborious.