如今全國各地城鎮化建設正在如火如荼的進行中，混凝土的需求是相當大的，混凝土攪拌一體機也逐漸在城鎮地區流行了起來。我們都知道，施工地點的環境都是不太好的，攪拌泵經常會沾滿污垢，而且混凝土殘?jiān)幚聿粡氐滓矔?huì)對攪拌一體機有損壞，因此，經常清洗攪拌泵是很有必要的。我們經常能看到兩名買了同一臺型號攪拌泵的客戶，過了一段時間，其中一個客戶的攪拌泵還是嶄新的，保養得很好，而另一名客戶的攪拌泵從外表看來就已經很陳舊了，而且小毛病不斷。這就是因?yàn)椴唤?jīng)常清洗的緣故了！

Nowadays, the urbanization construction all over the country is in full swing, the demand for concrete is quite large, and the concrete mixing machine is also gradually popular in urban areas. As we all know, the environment of the construction site is not very good. The mixing pump is often covered with dirt, and the incomplete treatment of concrete residue will damage the mixing machine. Therefore, it is necessary to clean the mixing pump frequently. The appearance of one of the pumps was very old, and one of the pumps had been maintained for a long time, but one of the pumps was still very old, and the customer could see that one of the pumps had been in good condition for a long time. This is because you don't often clean it!

混凝土攪拌一體機清洗注意事項：

Precautions for cleaning of concrete mixing and pumping machine:
               

1混凝土攪拌拖泵開機前要先查看各控制器是不是出色，停工后用水和石子倒入攪拌筒內10~15分鐘進行清洗，再將水和石子清理出去。操作人員如進入攪拌筒內清洗時，除堵截電源和卸下熔斷器外，并須鎖好開關箱。

1. Before starting the concrete mixing pump, check whether the controllers are excellent. After shutdown, pour water and stones into the mixing drum for 10 ~ 15 minutes for cleaning, and then clean the water and stones. If the operator enters the mixing drum for cleaning, in addition to blocking the power supply and removing the fuse, the switch box must be locked.

2開啟泵送功能泵水用清洗球清洗管道。

2. Turn on the pumping function, pump water and clean the pipeline with cleaning ball.

3禁止用大錘擊打的方法根除積存在商品混凝土拌合機筒內的殘留混凝土，只能用鑿子慢慢根除。

3. It is forbidden to remove the residual concrete accumulated in the cylinder of commercial concrete mixer by hammering, but only slowly with chisel.

4在嚴寒季節，工作完畢后應用水清洗混凝土攪拌機滾筒并將水泵、水箱、水管內積水放凈，防止水泵、水箱、水管等凍壞。

4 in severe cold season, after the work is finished, the drum of concrete mixer shall be cleaned with water, and the accumulated water in water pump, water tank and water pipe shall be drained to prevent freezing damage of water pump, water tank and water pipe.

以上是關于混凝土攪拌一體機清洗流程的相關內容介紹，希望對大家有所幫助，想要了解更多內容歡迎點擊攪拌一體機http://www.wishnailspa.com官網。

The above is about the concrete mixing machine cleaning process related content introduction, hope to help you, want to know more content, welcome to click the mixing machine http://www.wishnailspa.com Official website.