攪拌一體機增壓器的作用就是提高發動機進氣量，讓車輛動力更強勁。但增壓器的工作環境對冷卻、潤滑和動平衡有極高的要求，因此，為了延長增壓器的使用壽命，通過以下4個方面來對攪拌一體機增壓器進行日常保養：

The function of the supercharger of the integrated mixer is to increase the air intake of the engine and make the vehicle more powerful. However, the working environment of the supercharger has extremely high requirements for cooling, lubrication and dynamic balance. Therefore, in order to extend the service life of the supercharger, the daily maintenance of the supercharger of the mixer is carried out in the following four aspects:

1、冷車時不可著車就走

1. Don't leave when the car is cold

車輛停駛一夜以后，機油因為重力作用會流回到油底殼中，在啟動發動機后要怠速運轉一分鐘左右讓機油循環建立，使增壓器浮動軸承得到充分的潤滑后再起步行駛。

After the vehicle is stopped for one night, the oil will flow back to the oil pan due to gravity. After starting the engine, it is necessary to run at idle speed for about one minute to establish the oil circulation, so that the floating bearing of the supercharger can be fully lubricated before starting.

2、高速運行后不要立即熄火

2. Do not shut down the engine immediately after high-speed operation

增壓器在工作的時候轉速很高，高速行駛后若是立即熄火，機油供給會突然中斷，此時增壓器仍在高速旋轉，這樣浮動軸承內的機油很快會被磨干，浮動軸承就會受到損傷。正確的做法應該是在熄火前怠速運行少一分鐘再熄火。

When the supercharger is working, the speed is very high. If the engine is shut down immediately after driving at high speed, the oil supply will be interrupted suddenly. At this time, the supercharger is still rotating at high speed, so the oil in the floating bearing will be dried quickly and the floating bearing will be damaged. The correct approach should be to run at idle speed for at least one minute before shutting down the engine.

3、機油和濾芯不能馬虎

3. The oil and filter element should not be sloppy

增壓發動機的運行環境都比較惡劣，所以對機油的要求相對也較高，在選擇機油的時候好按照廠家要求的粘度和級別來使用更換。濾芯就更不用說了，必須使用正規廠家的產品，如果使用劣質濾芯，會對增壓器的浮動軸承造成損害，嚴重會導致轉子抱死，增壓器報廢。

The operating environment of supercharged engines is relatively bad, so the requirements for engine oil are relatively high. When selecting engine oil, it is better to use and replace it according to the viscosity and grade required by the manufacturer. Not to mention that the filter element must be the product of a regular manufacturer. If the inferior filter element is used, the floating bearing of the supercharger will be damaged, and the rotor will be locked and the supercharger will be scrapped.

4、空濾也同樣重要

4. Air filtration is equally important

空濾是否正常也會關系到增壓器，因為增壓器軸承腔的密封主要是依靠兩邊的氣壓差。很多時候增壓器串油都跟這個有關，有時車主換下的串油增壓器可能只是次品空濾或者是空濾堵塞造成的。

Whether the air filter is normal will also affect the supercharger, because the sealing of the bearing cavity of the supercharger mainly depends on the air pressure difference on both sides. Many times, the oil spilling of the supercharger is related to this. Sometimes the oil spilling supercharger replaced by the owner may be caused by defective air filter or air filter blockage.

對攪拌一體機增壓器進行日常保養的相關內容就到這里了，您對此可以來進行詳細看看，希望能夠給您幫助！更多關注，來網站http://www.wishnailspa.com咨詢吧！

That's all for the routine maintenance of the supercharger of the mixer. You can have a detailed look at it. I hope I can help you! More attention, come to the website http://www.wishnailspa.com Consult!