自動上料攪拌機運行的使用規范
來源：http://www.wishnailspa.com/日期：2022-10-03
概述：自動上料攪拌機運行的使用規范是怎樣的？這里小編為大家介紹一下有關自動上料攪拌機運行使用規范的一些相關信息。
What are the operati
自動上料攪拌機運行的使用規范是怎樣的？這里小編為大家介紹一下有關自動上料攪拌機運行使用規范的一些相關信息。
What are the operation specifications of the automatic feeding mixer? Here, we will introduce some relevant information about the operation and use specifications of the automatic feeding mixer.
1、自動上料攪拌機在運輸砼的過程中，攪拌筒不得停止轉動，以免混凝土產生離析現象。
1. During the transportation of concrete, the mixing drum of the automatic feeding mixer shall not stop rotating to avoid segregation of concrete.
2、自動上料攪拌機上路行駛時，卸料溜槽降低處并轉與車身垂直部位，用鎖緊裝置把卸料溜槽鎖緊在機架上，防止由于不固定而搖動，造成傷人事故和影響其它車輛運行。
2. When the automatic feeding mixer is running on the road, the discharge chute is lowered to the lower position and turned to the vertical position with the vehicle body, and the discharge chute is locked on the rack with a locking device to prevent shaking due to unfixed, causing injury accidents and affecting the operation of other vehicles.
3、車輛須嚴格按照廠家的載質量運營，不能超載。
3. The vehicle must be operated in strict accordance with the manufacturer's load weight and cannot be overloaded.
4、啟動水泵開關時，須保證水泵里有水，水泵連續運轉時，切勿將水閥關閉。冬季停放時供水系統須排空，并打開所有關閉球閥使水流出。
4. When starting the water pump switch, ensure that there is water in the water pump. Do not close the water valve when the water pump is running continuously. When parking in winter, the water supply system must be drained, and all closed ball valves must be opened to allow water to flow out.
5、對于新購置的自動上料攪拌車，在使用前須對底盤及上裝所有涉及到螺釘?shù)牡胤竭M行從新加固后方可運營。
5. For the newly purchased automatic feeding mixer, the chassis and all places where screws are involved must be reinforced before use.
6、減速機使用工作100小時須更換潤滑油，以后每工作1000小時或一年更換一次潤滑油（取其中時間短者）。新車工作累計滿300小時后須更換液壓油和液壓油濾清器濾芯。
6. The lubricating oil must be replaced after the reducer has been used for 100 hours for the first time, and then every 1000 hours or once a year (whichever is shorter). The hydraulic oil and hydraulic oil filter element must be replaced after the new vehicle has been operated for 300 hours for the first time.
以后每工作1500小時或六個月（取其中時間短者）更換液壓油和液壓油濾清器濾芯。更換液壓油時須先把油箱系統內原來的液壓油全部放完后才能加入新的液壓油。
Replace the hydraulic oil and hydraulic oil filter element every 1500 hours or six months (whichever is shorter). When replacing the hydraulic oil, drain all the original hydraulic oil in the oil tank system before adding new hydraulic oil.
When the truck is stopped, turn the operating handle to make it in the middle position (even if the mixing drum is in a static state). Non operators are forbidden to operate, and operators need to operate according to the instructions provided by the manufacturer. Come to our website for more information http://www.wishnailspa.com Consult!
全國服務熱線
點擊撥打服務熱線：400-879-1999
