混凝土攪拌機發生故障時時候，若沒有及時將攪拌罐內的清理出來，時間一久將會凝固，會給我們帶來很大的經濟損失。那么你知道在緊急情況下如何清理混凝土攪拌機內的混凝土嗎？

When the concrete mixer breaks down, if the mixing tank is not cleaned in time, it will solidify after a long time, which will bring us great economic losses. Do you know how to clean the concrete in the concrete mixer in an emergency?

方法一：

Method 1:

1、準備好緊急驅動軟管，將故障混凝土攪拌機熄火，卸下液壓馬達上的高壓油管接頭。

1. Prepare the emergency drive hose, turn off the faulty concrete mixer, and remove the high-pressure oil pipe connector on the hydraulic motor.

2、將救援車熄火，將其液壓馬達的高壓油管卸下，并與故障車上的對應接頭用緊急驅動軟管相連。

2. Turn off the rescue truck, remove the high-pressure oil pipe of its hydraulic motor, and connect it with the corresponding connector on the faulty truck with the emergency drive hose.

3、發動救援車，將其操縱手柄撥出料位置，故障車內的商品混凝土即被排出。

3. Start the rescue truck and turn its operating handle to the discharge position, and the commercial concrete in the faulty truck will be discharged.

4、緊急驅動完畢后，將驅動軟管卸下，并恢復兩車原狀。

4. After the emergency drive is completed, remove the drive hose and restore the two vehicles to their original state.

方法二：

Method 2:

1、若個方法實行有困難，則采用以下方法，立即排出商品混凝土。

1. If the above methods are difficult to implement, the following methods shall be adopted to discharge the commercial concrete immediately.

2、在托輪和滾道之間放入木楔，以控制攪拌筒的旋轉，一定要注意；將發動機熄火，拆松液壓馬達的一根高壓油管，攪拌筒可自由旋轉，控制攪拌筒的旋轉，使維修孔轉到下部，然后打開維修孔，清理出筒內商品混凝土。

2. Put a wooden wedge between the supporting wheel and the raceway to control the rotation of the mixing drum. Be careful; Turn off the engine, dismantle a high-pressure oil pipe of the hydraulic motor, the mixing cylinder can rotate freely, control the rotation of the mixing cylinder, make the maintenance hole turn to the lower part, then open the maintenance hole, and clean out the commercial concrete in the cylinder.

此時一定要注意，商品混凝土排出完畢后，恢復混凝土攪拌機原狀。緊急清理混凝土攪拌機內商品混凝土是我們每個混凝土攪拌機司機都應該會的，在混凝土攪拌機發生故障的時候，及時清理，將損失降到低。

At this time, it must be noted that after the commercial concrete is discharged, the concrete mixer shall be restored to its original state. Emergency cleaning of commercial concrete in the concrete mixer is what every concrete mixer driver should know. When the concrete mixer breaks down, it should be cleaned in time to reduce the loss.

混凝土攪拌機的混凝土凝固怎么辦？以上給您講解了兩個方法，您可以作為參考，根據自己的實際情況來嘗試下，當然要做好充分的提前了解，行事。更多相關內容就來我們網站http://www.wishnailspa.com咨詢！

What about the concrete solidification of the concrete mixer? The above two methods have been explained to you. You can try them according to your actual situation as a reference. Of course, you should fully understand in advance and act safely. More relevant content will come to our website http://www.wishnailspa.com consulting service