Every user wants to see the normal operation of concrete mixer, which requires users to pay attention to the following three links when using the mixer:

　　1.攪拌機運行前:混凝土攪拌機運行前后，傳動機構、工作裝置、制動器等。應進行可靠的檢查和緊固，以確保正常運行。大齒圈、皮帶輪等部件上應安裝防護罩，攪拌筒、支撐傳動和運動部件以及倉門、斗門和軌道內不得有異物卡住。

　　1. Before mixer operation: before and after concrete mixer operation, transmission mechanism, working device, brake, etc. Reliable inspection and fastening shall be carried out to ensure normal operation. Protective cover shall be installed on the big gear ring, belt pulley and other parts. There shall be no foreign matters stuck in the mixing drum, supporting transmission and moving parts, bin door, bucket door and track.

　　2.混合器正在運行:

　　2. Mixer running:

　　(1)進料時，嚴禁將頭或手伸入料斗和機架，操作時不得用手或工具等東西伸入攪拌筒扒料卸料。

　　(1) When feeding, it is strictly forbidden to put the head or hand into the hopper and rack, and do not use hands or tools to reach into the mixing drum to pick up and discharge materials.

　　(2)料斗上升時，禁止在料斗下工作或行走。料坑底部應為料斗提供一個枕頭，在清理料坑時，料斗應使用鏈條固定。

　　(2) When the hopper rises, it is forbidden to work or walk under the hopper. A pillow shall be provided for the hopper at the bottom of the pit, and the hopper shall be fixed by chain when cleaning the pit.

　　(3)向攪拌筒加料應在運行中進行；添加新材料只能在攪拌機中所有的原混凝土卸載后進行。除反向卸料外，不要中途停止攪拌機或在攪拌機滿載時啟動攪拌機。

　　(3) The charging of the mixing drum shall be carried out in operation; the addition of new materials can only be carried out after all the raw concrete in the mixer has been unloaded. Do not stop the mixer midway or start the mixer when the mixer is fully loaded, except for reverse discharge.

　　(4)作業時，如故障不能繼續運行，應立即切斷電源，將攪拌筒內的混凝土清理干凈。

　　(4) During operation, in case of failure, the power supply shall be cut off immediately and the concrete in the mixing drum shall be cleaned up.

　　3.攪拌機運轉后:當混凝土攪拌完成或預計停止1小時以上時，除了排出剩余的材料外，還應將石頭和清水倒入振動桶中，并打開攪拌機，將附著在桶上的砂漿清洗干凈后排出。桶內不得有積水，以防桶和葉片生銹。同時，還應清理攪拌筒外積聚的灰塵，以保持機器的清潔和完好。

　　3. After the mixer is running: when the concrete mixing is completed or it is expected to stop for more than 1 hour, in addition to discharging the remaining materials, stones and water should also be poured into the vibrating bucket, and the mixer should be opened to clean the mortar attached to the barrel before discharging. There should be no water in the barrel to prevent the barrel and blades from rusting. At the same time, the dust accumulated outside the mixing drum should be cleaned to keep the machine clean and intact.

　　以上是關于混凝土攪拌機運行時需要注意的相關事項，希望對大家有所幫助，想要了解更多內容歡迎點擊我們的http://www.wishnailspa.com網站。

　　The above is about the concrete mixer operation need to pay attention to the relevant matters, hope to help you, want to learn more, welcome to click our http://www.wishnailspa.com Official website.