Today, the small editor of Laizhou Jufeng Machinery Co., Ltd. will give you a detailed introduction to the safe use of automatic concrete feeding mixer, and let you know more about Laizhou Jufeng Machinery Co., Ltd.

1、冬期施工時，應切實做到:開機前檢查是否結冰;下班時認真排除拌筒內及供水系統內殘存積水，關閉水泵開關，將控制手柄置于“停止"位置。

1. During winter construction, it is necessary to check whether there is icing before starting the machine; when off duty, carefully remove the residual water in the mixing drum and water supply system, turn off the water pump switch, and put the control handle at the "stop" position.

2、混凝土攪拌車卸料時，如發現水分蒸發，塌落度偏低不能滿足用戶要求時，可適當向筒內加水，然后以10-14r/min的速度旋轉30轉后卸料，使混凝士充分攪拌。

2. When the concrete mixer truck is discharging, if it is found that the water evaporates and the slump is too low to meet the user's requirements, water can be properly added into the cylinder, and then the concrete can be discharged after 30 rotations at the speed of 10-14 R / min, so that the concrete can be fully mixed.

3、混凝土攪拌車在空載運行過程中，攪拌筒不得停轉以免顛時造成滾道和托輪局部磕碰，導致托輪和滾道的異常損壞。

3. During the no-load operation of the concrete mixer truck, the mixing drum shall not stop to avoid local collision between the roller track and the supporting wheel, which may cause abnormal damage to the supporting wheel and raceway.

4、水箱的水量要經常加滿，以備急用。水箱加水前，必須打開放氣閥把箱內空氣放掉;沖洗時打開氣閥，沖洗完畢或者停用時應將水罐內氣體放掉。冬季停放時，水箱和供水系統里，不得有剩余水，防止凍裂，水箱僅在供水時加壓自動，混凝土自動上料攪拌機使用方法不要帶著加壓水箱在公路上行駛。

4. The water tank should always be filled up in case of emergency. Before adding water into the water tank, the air vent valve must be opened to drain the air in the tank; when the water tank is flushed, the air valve shall be opened, and the gas in the water tank shall be discharged after the flushing or shutdown. When parking in winter, there should be no residual water in the water tank and water supply system to prevent frost cracking. The water tank is only pressurized automatically when supplying water. The safe use of automatic concrete feeding mixer is not allowed to drive on the road with pressurized water tank.

以上是關于自動上料攪拌機如何使用方法的相關內容介紹，希望對大家有所幫助，想要了解更多內容歡迎關注我們的網站。

The above is about how to use the automatic feeding mixer safely. I hope it will help you. If you want to know more, please pay attention to our website.